Directions for use

Dosing method

Sewage treatment plant
Direct dosing to the sewage treatment plant or via the nearest toilet will greatly enhance the biological activity and keep the plant at peak operating efficiency.

A) On ships except passenger vessels Ineffective or septic sewage treatment can be reactivated and maintained in peak operating efficiency by dosing Unitor™ Gamazyme™ 700FN direct in the tank or via the nearest toilet. To reactivate the plant, 1kg Unitor™ Gamazyme™ 700FN should be mixed with 10-15 litres of hand hot (35°C) fresh water, left for 10-15 minutes (stirring periodically) for the bacteria to activate before dosing into the tank daily until the system is operating efficiently. Maintenance dosing of 0.1 - 0.25kg weekly will keep the system operating effectively. Replacing the toilet cleaner in use by Unitor™ Gamazyme™ BTC (biological toilet cleaner) will dose millions of specialised bacteria into the system. These powerful bacteria will digest organic material lining the pipes and boost the bacterial activity in the sewage treatment plant, keeping it operating at peak efficiency.

B) On passenger vessels
The applications is the same as mentioned above, but the dose rates are different.

The dose rate depends on the number of people on board the vessel. As a rule of thumb use 50 gram per m3 of the volume of the sewage tank. Then a weekly dosage of 10 gram per m3 of the volume of the sewage tank.

An example of a cruise vessel with a sewage tank on 100 m3 and 2500 people and on a two weeks cruise. What is the consumption of Unitor™ Gamazyme™ 700FN?

Initial dosage: (50 g/m3 x 100 m3 ):1000 = 5kg
Weekly dosage: (10 g/m3 x 100 m3 ):1000 x 2 weeks = 2kg On this cruise, will be used. 7kg of Unitor™ Gamazyme™ 700FN

Tank cleaning
Holding tanks can be cleaned periodically or prior to entry without the use of dangerous toxic chemicals.

Grey and black water holding tanks, sewage tanks, sewage treatment plant should be flooded and pumped empty to clear excess soil before cleaning. Holding tanks must be fitted with an air manifold connected to a low pressure air line of sufficient volume to gently turn the mass of water within the tank. In sewage treatment tanks the normal air supply will suffice.
The tank should be filled to 75% capacity with fresh or sea water and the air supply turned on. Approximately 0.5kg of Unitor™ Gamazyme™ 700FN in 5 to 10 litres of fresh hand hot (35°C) water should be mixed and left for 10-15 minutes before dosing into the tank. Dosing can be either direct or via the nearest toilet. The tank should then be filled and left with the air on for at least 48 hours. The dose rate should be approximately 0.5kg per 500 litres tank capacity with a minimum dose of 5kg. Although Unitor™ Gamazyme™ 700FN is formulated for use in cold (15°C minimum) sea water, performance will improve with lukewarm (35°C) fresh water or sea water.

Pipe cleaning
Maintenance dosing will keep galley and sewage pipes clean and clear of organic residual wastes.

A liquid solution should be prepared by mixing of 0.5 kg of Unitor™ Gamazyme™ 700FN in 15 to 20 litres of hand hot (35°C) fresh water. Stir it and, if possible, leave for 15 minutes to reactivate the bacteria. Whilst constantly agitating this solution, 1 litre should be dosed into sinks, scuppers, showers, drains, waste disposal units, etc. each evening until the blockage is cleared. A maintenance dose once or twice a week can then be applied to keep the pipes in clean condition. Harsh toxic cleaners (acids, caustics, disinfectants) should not be used as these will kill off the bacterial action in the pipes. Alternatively, the pipes should be isolated and filled with the solution and left for up to 48 hours before draining. If necessary, further applications should be made until drains run clear.

NOTE: Severly scaled systems should be acid cleaned.

产品特性

• 粉末配方，易于使用

• 可生物降解

• 重新激活因过载，冲洗或使用侵蚀性清洁产品而变得无效的系统中的生物活性

• 消除对危险化学品的需求

• 具有成本效益，节省时间，金钱和人力

优势

• 消除与过载或堵塞的卫生系统相关的气味

• 无需人工进入即可清洁污水储存舱

• 清除被有机废物堵塞的管道和系统

• 清除缓慢排水的管道和排水孔中的有机物质

• 重新启动化粪池污水处理计划

• 使整个卫生系统保持最佳运行状态

Unitor™ Gamazyme™ 700FN 的配方可降解船上卫生管道工作系统

，储舱和海洋污水处理厂中过量的残余废物
。Unitor™Gamazyme™700FN中的专用菌株将消化油脂，脂肪
，污水，淀粉和其他有机化合物。

纸张，蛋白质和废品残留物的降解大大增加
，并且这些产生的气味减少。

Unitor™ Gamazyme™ 700FN中的细菌将定殖管道/舱系统中的废弃有机物质并降解废物，直至系统清洁。海洋污水处理厂的生物活性大大增加，因此植物可以处理更多的废物。令人讨厌的在厕所区域和通常与过载或阻塞系统相关的排水孔中的气味减少。

订购信息

Product Number                           Product name

571711                                       GAMAZYME 700FN 12KG

使用说明

加药方是

污水处理计划

指导给污水处理厂或通过最近的厕所将大大提高生物活性并使工厂保持最高运行效率
。

A) A）在客船以外的船舶上通过在水箱中或通过最近的马桶加入Unitor™Gamazyme™700FN指导，可以重新激活无效或化粪池污水处理并保持最高运行效率。为了重新激活植物
，1kg Unitor™Gamazyme™700FN应与10-15升手热（35°C）淡水混合，放置10-15分钟（定期搅拌），使细菌在加入水槽前激活每天直到系统有效运行
。每周0.1-0.25kg的维护剂量将使系统有效运行。更换Unitor™Gamazyme™BTC（生物厕所清洁剂）使用的马桶清洁剂将使数百万种特殊细菌进入系统
。这些强大的细菌将消化管道内的有机物质
，增强污水处理厂的细菌活性，使其保持最高效率
。

B）在邮轮上

应用与上述相同，但剂量率不同
。

剂量率取决于船上人数
。根据经验，每立方米污水池使用50克。然后每立方剂量为每立方米污水池10克。

一个带有污水箱的游轮的例子

100立方米和2500人，并在两周巡航
。Unitor™Gamazyme™

700FN的消耗量如下列算式:

初始剂量
：（50g / m 3×100m 3）：1000 = 5kg

每周剂量
：（10g / m3×100m3）：1000×2周=

2kg在这次巡航中，将使用。7kg Unitor™Gamazyme™700FN

135

Cleaning Chemicals

Gamazyme Cleaners MARINE CHEMICALS

清洁舱

可以定期或在进入之前清洁舱，而无需使用危险的有毒化学品。

灰色和黑色的水容器
，污水池
，污水处理厂应该被淹没并抽空，以清除多余的土壤
，然后再进行清洁。保温罐必须安装一个空气歧管，该空气歧管连接到足够容积的低压空气管路，以轻轻转动水箱内的水
。在污水处理池中，正常的空气供应就足够了。

应使用新鲜水或海水将水箱填充至75％容量，并打开空气供应。

大约剂量

将0.5kg Unitor™Gamazyme™700FN在5至10升新鲜手热（35°C）水中混合并放置10-15分钟
，然后加入罐中
。剂量可以是指导或通过最近的厕所。然后应该装满水箱并让空气开启至少48小时
。剂量率应为每500升容器容量约0.5kg
，最小剂量为5kg。

管路清洁

维护剂量将保持厨房和污水管道清洁
，并清除有机残余废物。

应通过在15至20升手热（35℃）淡水中混合0.5kg Unitor TM Gamazyme TM 700FN来制备液体溶液。搅拌
，如果可能的话，离开15分钟以重新激活细菌
。在不断搅拌这种解决方案的同时
，每天晚上应将1升装入水槽
，排水管

，淋浴器，排水管，废物处理装置等，直到堵塞被清除。然后可以施加每周一次或两次的维持剂量以使管道保持清洁。不应使用严酷的有毒清洁剂（酸，腐蚀剂，消毒剂），因为这些会杀死管道中的细菌。或者，应将管道隔离并用溶液填充
，然后在排水前放置48小时。如有必要，应进一步申请
，直到排水管畅通无阻为止。

注意: Severly缩放系统应酸洗

。